suzuki intruder wont startsuzuki intruder wont start

New pugs full rebuilt carb tank clean FILTER clean petcock new no pitched lines. Leak down test.?? Ran the new battery down trying to start it,,was g ona try and find some new plugs tomorrow,and I have the battery in charge now! Also make sure that you are getting good spark. Any ideas please? New comments cannot be posted and votes cannot be cast, Press J to jump to the feed. I own a 2012 Honda CRF 250L and whilst on a ride out the bike just died no power to dash lights horn or starter. Hello, I just got my hands on an 83 Honda CB1000 and Im having joyful time. Cant figure it out. Then i again charged the battery and this time bike didnt startup. So I just got a new battery for my bike as it was not starting. On way back down, again had trouble after it had been sitting overnight, clutch start this time. Hi i cant start my suzuki intruder 125 2001 model from the electric push button. But the question I have is it was all ok before the starter burned off. Talked to your tech support about my 1987 Yamaha FZ 600. Hi Ryan can you advice me. Still will only turn over but not start. HELP !!!!!!! 86 suzuki intruder.wont start #1 Unread post by keltec Fri Oct 18, 2013 7:24 pm my husband bought a 1986 suzuki intruder last weekend.rode 3 times and it then it wouldn't start.no lights nothing. Hi, this could be any number of things. 4/1016 BMC coloni malwani marve road malad (w) Mumbai 400095. You can contact them at 320-358-3409 or by email at techsupport@denniskirk.com, Hi 97cbr900rr. Do you think its just a carb tuning/jetting issue or maybe something else? Half turn like a dead battery or. Just as satisfying is the deep rumble from the reverse taper . Where to start. I did get it running by jumping the solenoid yellow wire to the hot wire which turns the engine over, if I hold the starter button down at the same time Im jumping the solenoid the bike starts and runs beautiful. Have a great day. For a better experience, please enable JavaScript in your browser before proceeding. There are few things that are more disappointing than getting psyched up to go riding only to be hit with realization that your motorcycle wont start. What might be the issue? Free shipping for many products! Make sure that air can pass through your air filter/intake. took the carb off gave it a good clean checked the float and everything in the carb checked, checked the filter in the tank, checked the gas pipe clear, checked for a spark and got a good. Hi my name is dean I have a yamaha yzf r1 bikes bean running fine till this afternoon it lost power got home switched off then got a bubbling noise from engine tryed to start her again wouldnt start a rotten smell of fuel could you point me in right direction or tell me what could be wrong?? A liquid-cooled, 45-degree V-twin engine delivers strong, torquey performance. Apr 21, 2014 2001 Suzuki VS 1400 Intruder. Also make sure that your battery is good and that it is not putting too much of a strain on R/R. You should be able to see a spark from electrode traveling to the metal. Do not be alarmed if you experience this because it is completely normal. Good morning i have a question . Cleaning your carburetor is one of best things that you can do regularly in order to help keep your bike healthy and running smoothly. The bike turns on, lights and all, but when I hit the start button it doesnt fire up something also sounds different. I took the bike to the shop and they were lost, they couldnt figure out why my bike wouldnt start. Compression tested too. MessageHi, My bike starts well when the engine is cold and I can ride for about 1km then it runs off. Hi I have pulsar 150 , 2007 whine i ride long time like 2hours, engine getting too heat then it wont start early , even I changed power plug but Its not starting, what is main problem . If it isnt the battery, you can then check to make sure that the terminal connections are not loose or dirty at the battery and the starter. I replaced the transistors on the spark unit. I have removed the spark plug and had cleaned and after that for a day there was no problem. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. Be sure to disconnect your battery! So since then I have purchased a new battery.and. If that doesnt fix it, feel free to contact our techs. A broken or loose vacuum line can result in too much air being drawn into the combustion chamber, which will alter the air/fuel mixture and not allow the engine to ignite the mixture properly. 375 Million Readers. You might want to save testing for compression until its the only thing left to troubleshoot. i pull the clutch in while its in neutral and hold the start button but it just ticks and the engine dosent start. 2003 HD FLHTCUI bike ran fine . Hello, I am having a bit of trouble with my 2002 Yamaha yzf-r1 starting. Below are some of the basic steps that you can take to get your motorcycle started and back on the road again. Sometimes it doesnt take much time to gunk up a carb. I checked the battery connections and they are tight. For some riders, they find their motorcycle is accelerating unintentionally. Ok I have a 2001 pw yz 80 pit bike to mess around on.I have cleaned the carb air filter and cleaned the spark plug too.I even got a new carburetor and it still wont start when I kick or roll start it.I really need help. Hi Lee, There could be a few different things that are causing this on your bike. Hooked up the cables to my friends truck and it fired up nice.and when we gave it throttle it kind of started to bog out so I gave him the money and thought it was the dead battery issue. 2008 Honda Nighthawk started fine when I bought it . Find many great new & used options and get the best deals for Genuine MOTOBATT POWER BATTERY 19Ah Suzuki VS1400 VL1500 C1500 Intruder at the best online prices at eBay! Well when I came out to go home it wouldnt start, no lights or power nothing. Now they are telling me that it is the cdi conversation unit. It has spark and the compression seems okay (about 110psi cold). Even on 3 cylinder. Ive been fiddling with it for most of the winter months. Then narrowing it downor pointing me to the next direction. Hi i have a suzuki gsxr 600 k6 in the shop , bike came in and the owner said the previous owner did bearings , big ends and mains , and he also did the head, he told me there was no compression, so as i opened the bike , i saw the timing was not set right, took out the motor , looked for bent valves and the was nothing, i re-seeted the valves , set the timing right, checked valve clearance and everything, bike does not want to start, injectors fuel pump everything 100%, but looking at the spark, took out one supressor plug and i fitted a new plug to see if it has spark, found that it only has spark when its not earthed , holding it close to the throttle body it sparks nice, holding it strait against the throttle body , then it does not have spark, can that be the problem why its not starting, and if so whats wrong? Getting compression. I will attempt to clean the carburetor soon. Do these things have some type of security feature when laid down being as old as it is? My favorite bike from back in the day. If not, switch out the plugs to check to see if that makes a difference. I have to wait for a couple of minutes before it starts again. Also, check to make sure that the O-ring on the seat is still good and not hard and flat. !!!!!!!!! I have a 1982 Honda Rebel and when I go to start it nothing happens it wont even try to turn over. I have adjusted the decompressor cables . Hi I have 125 scooter cleaned all carb and new battery new spark plug was running and riding good and today it wont start it firing up but just not enough to get the engine started, My bike has a starting problem. I checked the battery and it registered 13.2x volts. It sounds like it starts so you let off the button and it stops. Sitting for long periods of time can also dry out your fuel system. You can check out this article for troubleshooting tips-https://www.denniskirk.com/learn/how-to-diagnose-motorcycle The engine is turning over, but nothing is happening except for the fact that your frustration level is rising. You have already started on the fuel system, but while you wait for the choke plunger spring you could check the others. Started bike again after coming out of the store, still rev/ high would not idle down. Bike just clicks like a battery? If it starts it will smoke for a bit but should gain the compression needed. Any advise would be appreciated. Once you figure that out you can move on with troubleshooting. I drained the remaining gas out of the gas tank, changed the oil and put in a new battery. When you start here, you can keep tracing it back until you find your ignition or spark issue. They will be able to help you troubleshoot this further. Then let the carb dry. The lights come on, but nothing when trying to start. As dirt and fuel residue build up in the carburetor, the engine itself will run less efficiently. Medium. Hey Jon this sounds like a frustrating situation. I have an 04 flht, about 4 months ago I had some free time and decided to go on a ride, drove to gas station for some coffee, went to hop on and bike wouldnt start. Infinity Sports. I had it towed back home and just parked it for a few weeks. When I install charged air filter bike wont start. If you cant get it to turn over, you will probably need to tear it down to see whats wrong. Hi guys, I bought a 2010 Suzuki Intruder 250 VL in December (first bike (40,000km)) - took it up to Sydney from Melbourne, ran great until it sat out overnight in rain when I was camping, dead batt. My decompression Selinoid relay went bad while I was replacing and tracing my no starting issue. Mantwisting my mind!! Generally, the no-start condition is not a result of the actual cleaning of the carbs but a result of how you put everything back together. Suzuki intruder wont start. Fresh gas can make a huge difference in your engines ability to start and run. It never dawned on me that there was any other issue with the bike.. Dont know how to trouble shoot this issue. Whats wrong with my bike? If it helps, I just installed a new cdi, so that is not an issue. I am curious if there are any tips or tricks to get the chunks of rust out. On way back down, again had trouble after it. I rode it about 60 miles at end of season last year. Combustion test reads fine as well. then, main problem is kick start had struck and it pumping on oppositle side. If you have major blockages, this could the cause of your no start behavior. If I turn the bike off. I own a 2012 Triumph T100. Little more information.. Ive had the bike since it was at 13,500 miles and it is now at 23,000 and although it is a well kept bike, ive never changed the spark plugs. Now you are ready to start cleaning things up. Bout to dump it at my mechanics doorstepThought I could solve this..ugh. Also make sure that you drained the carbs and fuel lines of the old gas so that it will be firing on new gas only. I have a gsxr 750 k1.Bike was standing for 2months. I have an 02 gaze 1000 that would start fine. Coil? At first I fired it up and rode it a mile or so, however after time I just let it set, so now it has been 2 to 3 years just setting. Hi Ryan, I have a 1997 Suzuki GSX-R600. Why would the fuel pump just stop working like that. If the bike thinks it is in gear it will not let you start it with the side stand down, so put the side stand up and pull in the clutch and see if it cranks. What. Hey Harry, contact our Tech Support Team and they will be able to help troubleshoot step by step to find the issue. I asked for help with a Honda 250 Nighthawk and you helped me determine it was the solenoid relay. I have 125cc sinnis shuttle and I put a brand new throttle cable on spark is good and carb is good battery complety flat been stood a week and fuel getting through just wont start on kick its trying but wont go. Thanks again. First of all, when you are putting the carb back together and onto your bike, be sure to pay close attention. And when I was purchassing it from the owner it had a dead battery so we. CDI ?? What is ur view? Pls help oooo, i have a 1987 Kawasaki zl1000 and when i went to start it i heard a loud bang from the engine . If this post is about bodywork, accident damage, paint, dent/ding, questions it belongs in r/Autobody r/AutoBodyRepair/ or r/Diyautobody/ If you have tire questions check out https://www.reddit.com/r/MechanicAdvice/comments/k9ll55/can_your_tire_be_repaired/. Follow our articles tips on how to do compression and leak down tests. Once it starts draining down, the bike works perfectly. Id rather buy new then used. The air fuel ratio is good. 1996 Suzuki intruder won't start . I have a GSXR 1000 K5 Suzuki.Last night I webt riding and when I got back home I parked in yhe yard switched of the bike to close the gates.when I want to start my bike again it doesnt want to start.I have done the duh issues.when I switch the ignition on.all my lights go on.but my petrol pump doesnt reset/buildibg pressure. Reminder, the bike ran just fine before I run out of gas. To test your spark plugs, remove them from the cylinder head and then plug them back into the plug cap. It still may be the battery. So I put it on the lift and tightened the chain, which Ive done before. If you have a multi-meter you can troubleshoot to see what the culprit is. I like things thst work every time and reliable all the time. Battery is brand new and charged. All seemed normal. I rode it to work Saturday, Sunday, and yesterday. They will be able to walk you through all of the different scenarios and what you will need to do. What do you think is the problem ? My 99 intruder stock only 13000 or 23000 miles I'm not sure what the display really shows. Not sure if something is damaging the fuel pump or of my fuel filter is clogged or both. Any ideas Unread post The bike starts fine in the morning and after work. Thanks for posting on r/MechanicAdvice! Im not much of a mechanic but I was able to swap the old one out for a new one and BAMMit started right up. I have since stripped it right back, iyt of frame. Feel free to contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com to help you further. sincerely, Lee. It obviously wont start. Any advice please No spark or weak spark? What else could be the problem.? I Have Jet Automatic Motorbike Which I Bought It The 3th April 2015,It Has A Problem,It Doesnt Wanna Start.I Cleaned The Carburettor And I Check The Plug And Cleaned It And it Does Spark,After Ive Done It I Started My Motorbike Still It Doesnt Start.Please Help Me. Is there any spark at all? Since getting the bike home, I have not been able to start it again. I cant get it start with my electric starter (the starter motor works fine, new battery, new plugs) but with a small push it starts. Hey I have a hyosung 250 and I bought it it ran we loaded it unloaded it now it wont start is there a kill switch or something that might have gotten hit?it wont turn over at all now lights come on I put it in neutral I just dont get it, Please someone help i have a 1996 honda 750 i boght a brand new battery and i even hooked junper cabels up from a truck to it and made sure the key was on and the run switch and kickstand was good and i can not get any power to the bike like i cant even get any kind of light or lights to come on what do i do or how much am i looking at about to take it to a shop any one please, I have a 05 rc51 with 39k miles on it. Rocdahitman. Thanks Mark No test on 1,2 or 4at the time though. Got it home, leaked oil, started rough, kept stalling and smoking. Hey Richie, I would clean the carbs on the bike, especially if has been sitting for a while with ethanol gas. Carbs been synchronized. Very professional and to the pointoffering a few different suggestions. If the RPMs go up, youve found your problem. New ignition switch on order. Thanks to everyone who responded. For help troubleshooting, feel free to contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. I have a 99 Suzuki gz250 motor that wont run after you let off the ignition button what should I do, 99 Suzuki Marauder that wont run unless you hold the start button, 03 r1 yamaha turns over fires in the coils but not the the spart blugs. What is your take on this? Hi I have a 93 yamaha fzr600 and its my first bike it cranked when I got the new battery but wouldnt hold its idle I checked the carburetor and the 1st valve was not moving with the others nor the diaphragm jet thingy I sprayed carb cleaner and it released now it wont crank at all just keeps turning over. So I drained the tank and purchased some Seafoam. And as im righting this i M checking. I am in total confusion. If it stalled while riding check the battery,most likely a connection. The battery had a tender on it and finally needed to be replaced this spring which I did. I took a trip to the store the other day and noticed first that my bike would not idle down at stop signs or lignts it continued to rev/high. Try cycling the fuel pump about 5 times to get the gas pushed through. Hit us up at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your issue step by step. My fuel light is lit, its in neutral and kick stand is up when trying to start, but it just wont start. Plugs are getting fire. My bike turns over and over and does not start. Thank you. Check to make sure you are getting a good spark. A teacher walks into the Classroom and says If only Yesterday was Tomorrow Today would have been a Saturday Which Day did the Teacher make this Statement? 6 Reasons Why Your Motorcycle Accelerates By Itself. I dont think it has one. please my motorbike cant start because the electrodes from coil to the plug wasnt enough to spark what should i do? Hey Mike, Does it seem like it is flooded? Make sure the fuel lines are not clogged or pinched. SiteMap, Copyright 2005-2020 Speedy Auto All Rights Reserved, Motorcycle Repair: Charging Problem, test readings, signal lights, Motorcycle Repair: wet plug foul, yamaha rd 250, check air filter, Motorcycle Repair: size of flywheel puller, honda cb400n, metric scale, MotorcycleRepair:oilchange,bikebandit,yamaharadian, MotorcycleRepair:Gaspetcockonvirago500,virago500,bikebanditcom, Ford Repair: FORD GRANADA 1977, 1977 ford granada, vacuum leaks, UK Car Repair: VW golf 1.6 auto carb 1977, starts but dies, vw golf 1, crankcase breather, Volvo Repair: 1999 S70 Electrical Quirks, fuse box, electrical portion, Audio Systems: stereo problem, protection circuits, dear bill, Truck Repair: glow plugs, glowplugs, glow plugs, Ford Repair: blowing fuse, rear defroster, amp meter, Dodge: 97 dodge intrepid, advanced auto parts, intake plenum, Auto Insurance Claims: accident, own insurance, daughter lives. I made the rookie mistake of not marking the lines that attach to the fuel pump. Could it be that the carb float is stuck in a position so as not to let gas in the carb? link to Can A Loose Motorcycle Chain Cause Vibration. Alternatively, let's try check and review the basics.Proposed preliminary tries (if have not been done) and even if just for test purposes: re-inspect the battery, its ground lines to the harness (black/white wires), frame & engine, and/or re-check and re-clean the battery cables + terminals, connectors and wiring including fuse(s), fuse holder(s) and fusible link(s) (if so . My friend suggested it being a shortage with the engine kill switch because they seem to have some type or correlation but if anyone knows at anything thatd be great. i would like to know if it helps anyone else please. Im getting spark and it sounds like it wants to turn over but wont. I have a 1999 Heritage Softail that wont start. 92 Suzuki intruder vs800. Close. probably a rookie error. I tried to start it and it started for a second and died. Soon as i back off throttle it rides fine. Hi Mark my sons got a Vuca Scooter its been standing for 2 years, what can I do to start it. If it is, run a test and make sure that you are actually getting spark. Hi Brandon, is there spark? i have a mt125 and having a problem starting it. started 3 weeks ago too.Battery went dead so I got a new one. I tested my stator as per your technical supports suggestion. Hey Ryan, thats an interesting issue. Have, spark (strong now) fuel (cleanno gunkgas tank was thoroughly flushed), in-line filter, good carbs, new coils, swithced out CDI, caps, wires, plugs, etc.but still only have 1/2 a bike. ITS pouring rain now. Nada. Once the bike gets running its acts fine and will fire right up. The most common culprit is the float. Am i headed in the right dirrection? Honda xr125L. My job is at risk for the cause of lack of transportationtransportation.. We suggest you to surf our . I turn petcock on and fuel just pours out of overflow tube. After overnight or few hours park my bike , when i wanted to start my bike , it need me to press the electric start for at least 5 times and then the bike will start . Press and hold button for a few seconds and it will the start. I ment I made it carbureted. So i was wondering could it just be a bad plug or could it be internal.? The battery is brand new, I replaced it and kept a battery tender on it, and the engine turns over. Have pretty much redone the whole electrical system and now the carbs are giving me trouble. Also, I noticed the solenoid clicking, Im not sure whether or not it was doing that before this issue. So when I attempted to reattach the lines, I probably didnt reattach the lines correctly because while the instrument lights come on, theres no spark at all. I have a 1987 Yamaha FZ 600. Put a new battery in it wont start tried to jump it solenoid just clicks so I tried to push start it and the tires spins and it just slows to ok a stop. $4,176. Kickstand Is up kill switch is off. Create an account to follow your favorite communities and start taking part in conversations. It ran just fine before I did the fuEl filter. Contact us at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your problem. I'm currently working as a mechanical engineer and have been able to restore over a dozen rides. Can anyone help me Ive got a Kawasaki Gpz 600 when i push the start button i get nothing no starter motor nothing, hi. i have a 1978 Kawasaki kz750, the engine wont fire up but will sit there and try to and tick while trying to turn on. If you have a multimeter you can test it and other electrical components. The bike started for the first time after winter storage, I rode it for about 5 miles. Bad battery connection? If your compression is bad, that could be your issue. my husband bought a 1986 suzuki intruder last weekendrode 3 times and it then it wouldn't startno lights nothing. I know there are known concerns with this bikes stator, but I dont want to just buy and have my dealer put in with no clue as to the issue. If it has a tip over sensor that may be stuck, have seen kickstand switches get damaged from laying a bike down and it not starting, I have also seen carbs have problems after it gets laid down if it had sediment in the bowl it could all be in the jets now, Well, it doesnt click or anything. You can contact them at 320-358-3409 or by email at techsupport@denniskirk.com. $5,905. When it stops, turn the key to off and then do it again. Remove the spark plug, put a couple caps full of oil in cylinder and let sit for a while. One of my mechanic budseven did a compression test on cylinder 3 (I was having issues with it warming upealier in the rebuild process. 320-358-3409 or by email at techsupport@denniskirk.com. Feel free to contact our tech support at 320-358-3409 or by email at techsupport@denniskirk.com. Earlier in the processyes.with bad rubber and worn seas. Now it won't start, the electric start kicks but nothing. Make sure that you reassemble everything properly. Ive tried with choke on and off. For more help, feel free to contact our Tech Team. My Honda msx 125 doesnt start, it cranks over and thats it. (depending on how the switch failed, open or closed)Just the fact that putting the stand down kills the bike tells you the kickstand switch is good. That plug will spark well and the engine will start!! Hi guys I have a yamaha vstar 650 that acts like it floods when sitting over night, I have to shut the petcock off when I shut her off and I have to fight to get it to fire up in the morning. This spring it fired right up and rode it twice with no problems. South Korea's Ministry of Education said Monday that six school students were among the dead, including one in middle school. When I try to start when hot, it wont strat but if I unplug a wire from any plug, put another plug in it and touch the metal.

Bristol Hippodrome Stalls Or Grand Circle, Kevin Brauch Wife, Julie Brown Obituary 2021, Articles S